Please wait a minute...
水泥技术, 2024, 1(3): 38-42    doi: 10.19698/j.cnki.1001-6171.20243038
  技术改造 本期目录 | 过刊浏览 | 高级检索 |

2 500t/d水泥熟料生产线烧成系统的热工分析及优化

山西昌灏环保科技股份有限公司,山西 长治 047508

Thermal Analysis and Optimization of the Pyro-system of2 500t/d Cement Clinker Production Line

Shanxi Changhao Environmental Protection Technology Co., Ltd. ,Changzhi Shanxi 047508, China

下载:  PDF (2720KB) 
输出:  BibTeX | EndNote (RIS)      
摘要 

2 500t/d水泥熟料生产线存在熟料易磨性差、氨水用量大、预热器C1出口温度高等问题。通过标定烧成系统预热器各级旋风筒进出口温度、压力、下料温度及重点部位的气体成分,分析了预热器系统运行过程中存在的问题。提出了优化分解炉煤粉管路,改造烟室和C4撒料板结构,提高缩口风速,改进旋风筒进口水平段和分解炉鹅颈管,增设阶梯式预燃炉等技改方案。改造后,预热器C1出口温度由340℃降至320℃,在保持NOx排放浓度45mg/m3不变的情况下,氨水用量从4.5kg/t.cl降低至2.6kg/t.cl,氨逃逸<5mg/m3,回转窑系统运行稳定。

服务
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章
赵武魁
关键词:  烧成系统  热工标定  结皮结圈  氨逃逸  阶梯式预燃炉    
Abstract: 

The 2 500t/d cement clinker production line of a cement enterprise has problems such as poor wearability of clinker, large ammonia dosage, and high exit temperature of preheater C1. By calibrating the inlet temperature, pressure, discharge temperature and gas composition in key parts of the cyclone cylinder within the preheater of the pyro system, the problems existing in the operation of the preheater system are analyzed. Technical reform schemes such as optimizing the pulverized coal pipeline of the calciner, transforming the structure of the kiln inlet chamber and the C4 sprinkler plate, improving the shrinkage gas velocity, improving the horizontal section of the cyclone cylinder and the gooseneck pipe of the calciner, and adding a stepped pre-combustion furnace. After the transformation, the exit temperature of the preheater C1 was reduced from 340to 320. Under the condition that the NOx emission concentration remained unchanged at 45mg/m3, the amount of ammonia water consumption was reduced from 4.5kg/t.cl to 2.6kg/t.cl, the ammonia escape <5mg/m3, and the operation of the rotary kiln system was stable.

Key words:  pyro system    thermal calibration    coating and knot ring    ammonia escape    stepped pre-combustion furnace
收稿日期:  2023-12-09                出版日期:  2024-05-25      发布日期:  2024-05-21      整期出版日期:  2024-05-25
ZTFLH:  TQ172.624  
引用本文:    
赵武魁.

2 500t/d水泥熟料生产线烧成系统的热工分析及优化 [J]. 水泥技术, 2024, 1(3): 38-42.
ZHAO Wukui.

Thermal Analysis and Optimization of the Pyro-system of2 500t/d Cement Clinker Production Line . Cement Technology, 2024, 1(3): 38-42.

链接本文:  
http://www.cemteck.com/CN/10.19698/j.cnki.1001-6171.20243038  或          http://www.cemteck.com/CN/Y2024/V1/I3/38
[1] 周桂胜.

5 000t/d水泥熟料生产线节能降耗改造 [J]. 水泥技术, 2024, 1(3): 32-37.

[2] 马纯辉, 臧剑波, 章利华, 张闯, 赵华.

水泥窑在线热工标定系统开发及应用 [J]. 水泥技术, 2024, 1(3): 58-65.

[3] 关长亮. 基于中子活化分析仪的水泥烧成系统游离氧化钙卡边控制方法研究[J]. 水泥技术, 2024, 1(1): 69-73.
[4] 梁乾, 陶从喜, 邓乾, 胡斯亮, 何明海. 5 000t/d水泥熟料生产线烧成系统节能降耗改造[J]. 水泥技术, 2023, 1(4): 55-59.
[5] 张冬冬, 王朝雄. SCR脱硝系统工艺方案设计及影响分析[J]. 水泥技术, 2023, 1(2): 32-.
[6] 陈学勇, 陈廷伟, 钱伟, 许龙旭, 庞小平. 5 500t/d水泥熟料生产线烧成系统的技术改造[J]. 水泥技术, 2022, 1(4): 15-20.
[7] 张滨, 郎济涵.
SNCR脱硝系统技术改造实践
[J]. 水泥技术, 2020, 1(6): 23-26.
[8] 狄东仁, 孟军, 肖静.
水泥生产线烧成系统电能消耗指标分析
[J]. 水泥技术, 2020, 1(5): 15-18.
[9] 贾兆义.
熟料包心料的产生原因及解决措施
[J]. 水泥技术, 2020, 1(3): 95-99.
[10] 马娇媚, 刘芳, 郭天代, 陶从喜, 彭学平. 5 500t/d六级预热器烧成系统的开发应用[J]. 水泥技术, 2017, 1(4): 22-25.
[11] 武晓萍, 徐俊杰. 高海拔地区水泥生产线技术诊断及优化[J]. 水泥技术, 2017, 1(1): 85-89.
[12] 高密军, 罗振.
我国水泥厂脱硝技术现状及展望
[J]. 水泥技术, 2016, 1(6): 84-86.
[13] 陶从喜, 董蕊, 钟克辉, 黄茂, 陈廷伟, 刘长锁, 苏兴辉, 梁乾, 陈学勇, 马玉国, 李国军. 2500 t/d烧成系统的改造[J]. 水泥技术, 2014, 1(6): 17-19.
[14] 吴清仁, 何琼宇, 赖洪光, 张拥军. 湿法窑降低能耗若干问题探讨[J]. 水泥技术, 2002, 1(增刊): 7-9.
[15] 陶从喜, 胡芝娟, 彭学平, 狄东仁. 5000t/d烧成系统技术开发 [J]. 水泥技术, 2002, 1(4): 5-9.
[1] . Review and Prospect of Engineering Practice of Waste Disposal in Cement Kiln in China[J]. Cement Technology, 2018, 1(1): 17 -21 .
[2] DI Dongren, TAO Congxi, CHAI Xingteng. Revision of Cement Energy Consumption Standards and Energy Saving Technology(Ⅰ)[J]. Cement Technology, 2018, 1(1): 22 -26 .
[3] LIU Yonggang, GAO Hongwei, XIAO Guiqing. Design Method of Road Structure Using Lean Concrete Base[J]. Cement Technology, 2018, 1(1): 27 -31 .
[4] LIU Xu, LI Liang. Investigation of New Medium Temperature Wear-resistant Alloy Steel[J]. Cement Technology, 2018, 1(1): 32 -34 .
[5] MA Debao. Finite Element Analysis of Inverted Cone in Raw Meal Silo[J]. Cement Technology, 2018, 1(1): 35 -38 .
[6] HAN Zhongqi. [J]. Cement Technology, 2018, 1(1): 38 -48 .
[7] XIE Jianzhong, LIAN Xuewen. Analysis and Solution of Segregation of the Kiln Ash in Continuous Raw Meal Homogenization Silo#br#[J]. Cement Technology, 2018, 1(1): 49 -53 .
[8] GUAN Laiqing, HE Yongxian. [J]. Cement Technology, 2018, 1(1): 54 -59 .
[9] WEI Can, ZHANG Yuanyuan, AI Jun. Application of Cement Intelligent Control System in Overseas Projects[J]. Cement Technology, 2018, 1(1): 60 -64 .
[10] JIN Shuang. [J]. Cement Technology, 2018, 1(1): 72 -73 .
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed   
    PDF Preview